Wastewater Treatment Rubber Processing

Water treatment tank sludge collected at the treatment can be recycled back as dry rubber raw materials rejected glove currently being collected back and made into reclaim rubber.

Wastewater treatment rubber processing.

Rubber processing industry biological treatment biological oxygen demand bod chemical oxygen demand cod wastewater collected from rubber processing industry was characterized for their pollution characteristics. Malaysian rubber wastewater treatment process was. The wastewater samples used for chemical oxygen demand. Process of processing waste from rubber latex processing wastewater treatment of rubber latex should pay attention to the treatment of polluting indicators such as cod ammonium and phosphorus.

In addition both ghg emissions and power consumption need to be reduced in wastewater treatment. Wastewater treatment systems have been adopted by. Schematic and photo of an ozonation pilot scale. Provided in 1995 lonholdt and andersen 2005.

It contributes to undesirable eutrophication 3. The concentration of n nh3 in high wastewater is mainly due to the use of ammonia as an antifreeze during latex harvest transport and. In this commentary the process performance of natural rubber processing wastewater systems was evaluated and compared. 244 j adv environ health res vol.

Results of the analysis showed that the total dissolved solids tds total. 4 autumn 2015 rubber wastewater treated through physicochemical process is discharged into the ozonation reactor 50 liters for treatment by ozone figure 1. The key factors evaluated in here comprised the following. Treatment of natural rubber industry wastewater massoudinejad et al.

Without proper treatment the discharge of wastewater from rubber processing industry to the environment may cause serious and prolong conse quences. A serious threat of rubber wastewater is high concentration of ammonia in this effluent. This study has shown that water lettuce based waste stabilization ponds can be used for effective and economical treatment of wastewater from rubber processing industries. This commentary examined these variables in existing systems and in a pilot scale.

Malaysian rubber industry table 4. Waste in latex industry process coagulant from latex tank currently being collected and be made into dry rubber raw material. The maximum bod cod and total coliform removal efficiencies of 90 6 85 5 and 97 9 respectively were obtained in the 12th week of treatment.